1. The yacht

2. The accident

3. Investigation

4. Prosecution

5. References

6. Sources

Cheeki Rafiki was a Bénéteau First 40.7 sailing yacht. Her sinking on May 16, 2014 resulted in an extended debate over the safety of modern sailing boats. The yacht lost her keel about 720 nautical miles Southeast of Nova Scotia and subsequently capsized. Rescue services found her upturned hull before it sank but the crew – four English men – was never found.

The yacht

Central to the later investigation was the construction of the hull and especially the link between the hull and the so-called "matrix", an inner layer that was embedded in the lower part of the hull to give it the necessary stability and stiffness. The keel was secured to the hull by ten bolts; nine of them 24mm in diameter and one 14mm. They were laminated into the keel, and put through the outer hull, the matrix, and a steel washer, and then secured with nuts. The building process and the construction fulfilled the CE-seaworthiness Classification of category A (ocean), in the version valid at the time of building. Additionally, the construction process had been surveyed by Bureau Veritas.

The accident

On May 17, more than 24 hours after the last contact with the ship, the container vessel Maersk Kure identified Cheeki Rafiki{{'}}s hull, upside-down. The keel was missing, but the rudder was still in place. Due to bad weather conditions, the wreck could not be investigated further. Only about one week later could a ship of the US Navy send a diver to the still-floating wreck. This confirmed the life raft was still secured to its storage location; the crew had not had the time to bring it out. Consequently, the search was terminated, because any hope of finding the crew alive was in vain. The maximum time somebody can survive in water of 16 °C is about 15.5 hours.^[1]

Investigation

The accident resulted in heated discussion amongst yachtsmen over the safety of sailboats and particularly over the construction and dimensioning of the connection between keel and hull, which had obviously failed in this case, but is of utmost importance for a sailing vessel. There were speculations whether the shipyard had fallen below the margins for required hull stability to cut costs as a measure to win customers in the highly competitive market for affordable yachts.^[2] The report of the British Marine Accident Investigation Branch showed that the construction did satisfy the relevant construction specifications available at the time of construction. It even almost passed the revised ones at the time of the accident. Therefore, the shipyard could not be held liable for the lack of stability.^[1]

Furthermore, the crew could also not be blamed for the accident, because they were competent and the skipper was in the possession of all required certificates for such a voyage. At the time of the accident, the wind blew with force 7, which is rough but still completely within the limits for which such boats are constructed. The accident investigation report points out though, that it's unclear whether the ship was even allowed to set to sea under applicable laws. This because, as a professionally skippered boat, there are extensive rules concerning equipment, crewing and yearly safety inspections. The later was overdue, but the operator was intending to postpone the inspection until the boat was back in England, so that he could avoid the costs of having to fly an inspector to the Caribbean.^[1]

The investigation report then tries to evaluate why the keel actually separated, even though technically, computationally and based on the weather at the place of incident there was no obvious reason for this. The wreck of the Cheeki Rafiki was not available for investigation, as it has not been found yet. So the MAIB had to find their conclusions from the few pictures of the rescue crews, the history of the boat and reports from sister ships. It was known that she had had a few groundings prior to the accident – experts investigated by the MAIB said that this was not uncommon for ships participating in races. The connection between hull, matrix and keel had been repaired several times already. Even experts are not normally capable of telling how such a repair would be properly done and how to tell that it was acceptably fixed. The recommendation from the manufacturer to remove the keel completely was considered best practice, its cost-effectiveness was questioned though.^[3]

The report concludes that the most probable cause for the accident was a failure of the glued link between the "matrix" (inner skeleton) and the outer hull. Similar damages could be observed in sister ships which where involved in groundings, too. Different repair yards said that they could only hardly determine the severity of such damages. Also, a skipper cannot easily determine whether a "light" grounding had caused any damage. The report states that Almost all [yacht owners and professional yacht skippers asked] agreed that groundings can occur when racing, and that if, in their opinion, it was a ‘light’ grounding, no inspection for damage was necessary^[8], while at the same time, there are several definitions for a light grounding:

• a grounding where the vessel did not stop;
• where the vessel only ‘bounced’ over the bottom;
• where no person was knocked off their feet as a result of the grounding;
• where the vessel grounded at slow speed; and
• where the vessel grounded on a soft bottom e.g. sand.^[4]

It is assumed that the structural damages in the hull of Cheeki Rafiki had not been sufficiently repaired after the previous groundings, such that the stability of the glued hull was compromised. It couldn't withstand the force of the increasing waves. The pictures show that the layers of the hull had separated. Some bolts could also have failed due to corrosion.

The extensive report gives many recommendations for improvements. However, it does not ask for increased stability requirements for keel-to-hull constructions.^[2]

Prosecution

Shortly after the report was published operating company Stormforce and its director Douglas Innes were charged, with Innes facing four counts of manslaughter by gross negligence.^[5][6] He was accused of insufficient maintenance to cut costs. The yacht was, according to the Crown Prosecution Service, not seaworthy for an ocean passage, as several bolts of the keel were corroded or broken even before the voyage: "A number of keel bolts had broken, causing it to detach from the hull. Many were broken and it had been like that for months. The yacht was therefore unsound, broken, and unsafe before the men left from Antigua."^[7] Innes pleaded not guilty.^[8]

The jury at Winchester Crown Court acquitted Innes of manslaughter, but they did find him and the company guilty of unsafe operation of the vessel and of failing to fulfill the requirements of the Merchant Shipping Act. ^[9] On May 11, 2018 Innes received a suspended sentence whilst his bankrupt firm Stormforce was fined £50,000^[10].

References

Sources

• Report on the investigation of the loss of the yacht Cheeki Rafiki and its four crew in the Atlantic Ocean, approximately 720 miles east-south-east of Nova Scotia, Canada on 16 May 2014; Marine Accident Investigation Branch (MAIB) Report 8/2015 [https://assets.digital.cabinet-office.gov.uk/media/55408664e5274a157200005b/MAIBInvReport_8_2015.pdf Report] (PDF), with [https://assets.digital.cabinet-office.gov.uk/media/554086e1e5274a157500003d/AnnexesToMAIBInvReport08-2015_CheekiRafiki.pdf Annexes] (PDF, english).
• [https://www.morganscloud.com/2015/06/25/cheeki-rafiki-report-misses-an-opportunity-to-make-boats-safer/ Lessons from Losses At Sea: “Cheeki Rafiki” Report Misses An Opportunity to Make Boats Safer]; Attainable Adventure Cruising; Juni 2016.

• Mwinyi Aboud Jumbe
• Mwiria Valerian Kilemi
• Mwirichia
• MWIT
• Mwitikila
• M. Witmark & Sons, Inc.
• Mwiyogo
• MW&K
• M.W. Kellogg Limited
• M.W. Kellogg Tower
• MW Kellogg Tower
• M. W. Kellogg Tower
• MWL Show
• MW (manga)
• MWMIK
• MWM (Motoren Werke Mannheim AG)
• MWM Motores Diesel Ltda
• MW Motorsport
• MWM Studios
• MWN
• MWNF
• MWNF Virtual Museum
• MWNN
• Mwogahendi
• M. Wolf (disambiguation)